Medium-sized waves can break wind turbines at sea like matches, according to Norwegian research. These waves occur even in small storms, which are quite common in the waters around Europe.

"The problem is, we still do not know exactly when the wind turbines may break," according to Professor John Grue from the Department of Mathematics at the University of Oslo, Norway. Grue is one of the world's foremost experts on wave research. In 1989, he discovered an inexplicable wave phenomenon called 'ringing', which is a special type of vibration that occurs when choppy waves hit marine installations. The discovery was made in a 25-metre long wave laboratory located in the basement of the mathematics building at Blindern Campus at the University of Oslo. So far, researchers have studied ringing in small and large waves, but as it turns out, ringing is more common in medium-size waves. For wind turbines at sea with a cylinder diameter of eight metres, the worst waves are those that are more than 13 metres high and have an 11-second interval between them. The ringing problem may increase significantly in the years ahead, according to Prof Grue, as governments increasingly turn to wind as a source of renewable energy. There are plans to build tens of thousands of wind turbines at sea around the Norwegian coast alone. "If we do not take ringing into consideration, offshore wind turbine parks can lead to financial ruin," he warned to the research magazine Apollon at University of Oslo. Today, the largest windmill parks at sea are outside the coasts of Denmark and the United Kingdom. They are nevertheless like small miniatures compared to Statkraft and Statoil's enormous plans on the Dogger Bank outside Scotland. This windmill park is to produce as much electricity as 60 to 90 power plants equivalent in size to Norway's Alta Hydroelectric Power Station. A windmill park with the capacity of two Alta power plants will be built outside Møre og Romsdal in West-Norway. "Thus far, it has not been possible to measure the force exerted by ringing. Laboratory measurements show that the biggest vibrations in the wind turbines occur just after the wave has passed and not when the wave hits the turbine," according to Prof Grue. "Right after the crest of the wave has passed, a second force hits the structure. If the second force resonates with the structural frequency of the wind turbine, the vibration is strong. This means that the wind turbine is first exposed to one force, and is then shaken by another force. When specific types of waves are repeated this causes the wear to be especially pronounced. This increases the danger of fatigue." It is precisely this secondary force that creates ringing and that the mathematicians until now have not managed to calculate. VIBRATION FREQUENCIES  All structures have their own vibration frequencies, whether they are wind turbines, bridges, oil rigs or vessels. When the vibration matches the structural frequency, things get tough. This phenomenon is called resonance, and can be compared to the steady march of soldiers on a bridge. If the soldiers march in time with the structural frequency of the bridge, it can collapse. The Norwegian University of Science and Technology and the Massachusetts Institute of Technology (MIT) have already made a number of calculations of ringing. Ecole Centrale Marseille and the French Bureau Veritas have also made such calculations. "Current models are the best we have, but the estimates are too rough and erroneous," Prof Grue continued. "The theories are applied far outside of their area of validity. This means that we cannot calculate the fatigue adequately." Ringing is not related to turbulence. It is, in fact, systematic and is about high underpressure at back of the cylinder. Internationally, very little has been done on this phenomenon. Prof Grue now has two doctoral research fellows calculating these movements. He also collaborates with the Danish research community on wind power at Risø National Laboratory and the Technical University of Denmark. "Ringing is very difficult to calculate. There is great uncertainty," he explained. "We want more precise descriptions of the physics of ringing. We are now trying sophisticated surface elevation models and complex calculations to reproduce these measurements accurately. We want to show that the ringing force arises systematically according to a general mathematical formula." Saga Petroleum has previously conducted an extensive set of measurements of the ringing force in waves. "These fit our measurements very well," said Prof Grue. The scientists must also consider whether the installations are in deep or shallow waters. "The structural frequency also depends on the conditions on the seabed. You can compare it to a flagpole in a storm. The flag pole vibrates differently depending on whether the pole is fixed in concrete or on softer ground. There has been no research on the connection between vibrations and the conditions on the seabed," according to Prof Grue. OIL INDUSTRY ALSO AFFECTED  Ringing does not just harm wind turbines, however. It has already been a great problem for the oil industry in Norway. The designers of the YME platform ,an oil field in the Egersund basin area in the central part of the North Sea, did not take ringing into account, and lost NOK 12 billion as a result. "It is possible to build your way out of the ringing problem by strengthening the oil rigs. However, it is not financially profitable to do the same with wind turbines," he added. Arne Nestegård, chief specialist in hydrodynamics at Det Norske Veritas (a Norwegian classification society organised as a foundation, with the objective of 'Safeguarding life, property, and the environment'), confirmed to Apollon that wind turbines at moderate depths may be exposed to high-frequency resonant oscillations if the waves are extreme, but they safeguard against this. Nestegård added that in the past twenty years, Det Norske Veritas has developed ringing models and that they are now working on improving the models for wind turbines at sea. The above story is based on materials provided by University of Oslo. The original article was written by Yngve Vogt.